Author Topic: Pre 75 Yamaha Trans Conversions  (Read 4093 times)

0 Members and 1 Guest are viewing this topic.

Offline Tahitian_Red

  • Legend
  • *****
  • Posts: 1109
  • Mugen ME480
    • View Profile
Pre 75 Yamaha Trans Conversions
« on: September 21, 2012, 04:05:06 AM »
Trying to figure out all the Close Ratio transmissions that will work in my 71 to 72 RT-1/2 lower ends?  I missed out on a DT-2MX transmission recently, so I'm looking for any that might work.  Thanks!
The "Factory Novice"
California, USA

'74 Suzuki TM100, '75 Bultaco 250 Pursang, '77 Honda XR75, '77 Suzuki RM125B, '77 Yamaha YZ400D, '79 Honda CR250RZ Moto-X Fox Replica, '83 Honda ME480RD Mugen

Offline vandy010

  • Legend
  • *****
  • Posts: 1982
  • #789 MX125a BMCC Brisbane
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #1 on: September 21, 2012, 08:16:17 AM »
a lot of the earlier cogs will swap over.
not always the case with the shafts.
but cogs/gears generally will swap quite happilly from one shaft to another always being mindfull that both gears (say 2nd as an example,), one from each shaft, go together and you keep checking the shimming. although i've not had a problem with shimming.
there is a difference in shifting forks if you choose to use the slightly later YZ250C gears.
i've had DT/RT1,MX250A,YZ250C gearsets side by side on the bench to verify.
ratio,s + beer + calculator = headphuck ???
have fun with it all...
"flat bickie"

Offline Tahitian_Red

  • Legend
  • *****
  • Posts: 1109
  • Mugen ME480
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #2 on: September 21, 2012, 09:44:54 AM »
Vandy,

Will a complete trans (not just gear swapping) from an MX250/360 swap into my RT-1 cases?  I thought Firko said once that the RT2MX gearbox would swap into DT-1/RT-1 cases.

 ???
The "Factory Novice"
California, USA

'74 Suzuki TM100, '75 Bultaco 250 Pursang, '77 Honda XR75, '77 Suzuki RM125B, '77 Yamaha YZ400D, '79 Honda CR250RZ Moto-X Fox Replica, '83 Honda ME480RD Mugen

Offline vandy010

  • Legend
  • *****
  • Posts: 1982
  • #789 MX125a BMCC Brisbane
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #3 on: September 21, 2012, 09:56:22 AM »
Been a while and cant remember exactly but more than lkely yes.
"flat bickie"

Offline firko

  • Superstar
  • ******
  • Posts: 6578
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #4 on: September 21, 2012, 10:14:48 AM »
Jay, the RT2MX trans slips straight in because they share the same cases with the RT1. The later case MX250/360 trans can be swapped in but work's needed as Vandy said. I went through the ' ratio,s + beer + calculator = headphuck' process on my bench when I was building the DT1 From Hell but that was back in the early 90's and I've long forgotten the details. I abandoned the research anyway when I found a rusty old YZ250 bottom end in a bike wreckers. I'm sure there's someone on this forum that knows the shaft/gear relationship between early and late gearboxes.....perhaps Davey Crockett or Iain ???
'68 Yamaha DT1 enduro, '69 Yamaha 'DT1 from Hell' '69 DT1'Dunger from Hell, '69 Cheney Yamaha 360, 70 Maico 350 (2 off), '68 Hindall Ducati 250, Hindall RT2MX, Hindall YZ250a , Cycle Factory RT2MX flat tracker, Yamaha 1T250J, Maico 250 trials, '71, Boyd and Stellings TM400, Shell OW72,750 Yamaha

Offline Tahitian_Red

  • Legend
  • *****
  • Posts: 1109
  • Mugen ME480
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #5 on: September 21, 2012, 11:42:24 AM »
Firko,

So....RT-1/2MX and YZ250/360A transmissions will bolt right in, but the MX250/360 will not?  Does it matter if you get the trans from a 250 or does it have to come from a 360?
The "Factory Novice"
California, USA

'74 Suzuki TM100, '75 Bultaco 250 Pursang, '77 Honda XR75, '77 Suzuki RM125B, '77 Yamaha YZ400D, '79 Honda CR250RZ Moto-X Fox Replica, '83 Honda ME480RD Mugen

Offline crossedup2

  • B-Grade
  • ***
  • Posts: 249
  • Never enough shed time.....
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #6 on: September 21, 2012, 01:03:19 PM »
Tahitian

Just done the swap, MX360 gear set into RT2 bottom end. The MX360 has a longer clutch shaft. You need the MX250 gear set. So mine is actually running the original 1 gear and close ratios for the rest. (I have ordered that MX250 clutch shaft for the next tear down.)

The only change you need to do is use the original 4th gear cog that slides using the shift fork. The original MX gear set has a larger area fork slot. This was done before beers!!!!! Nearly started cutting grinding bit realised that they are exactly the same part (size and gear teeth). This way you use the original RT1 fork as the MX for in very much different. MX360 is the closer set with the longer shaft.



Good luck with it and PM me if you need more information.

Peter B

Anything Yamaha. AT1, CT1 (X3), RT1, DT3 (x3), YZ125X,  YZ250E, YZ400D, IT175E, IT250H, XR500RC . Always looking for Pre 78 Yamaha stuff....

Offline firko

  • Superstar
  • ******
  • Posts: 6578
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #7 on: September 21, 2012, 01:39:31 PM »
Quote
    So....RT-1/2MX and YZ250/360A transmissions will bolt right in, but the MX250/360 will not?  Does it matter if you get the trans from a 250 or does it have to come from a 360?
Jay, the DT2MX/RT2MX and YZ250/360 A and B transmissions bolt straight into your RT1. The DT250MX and RT360MX have the same ratios and are identical so either will do the trick and I'mreasonably sure that the YZ A/B 250 and 360 also share the same ratios. Crossedup2 has answered the second part of your question and from memory that's exactly what Vandy and I worked out but couldn't remember ::). The 360 has a longer clutch shaft to allow for the balancer (I think!). I seem to recall the ratio situation being discussed here in the past and apparently the MX250 ratio spread is much better than that of the DT2MX, making the swap worthwhile. I've got one more spare RT1 engine that needs an overhaul so if I can locate an MX250 trans I may have a go at the conversion myself.
 






'68 Yamaha DT1 enduro, '69 Yamaha 'DT1 from Hell' '69 DT1'Dunger from Hell, '69 Cheney Yamaha 360, 70 Maico 350 (2 off), '68 Hindall Ducati 250, Hindall RT2MX, Hindall YZ250a , Cycle Factory RT2MX flat tracker, Yamaha 1T250J, Maico 250 trials, '71, Boyd and Stellings TM400, Shell OW72,750 Yamaha

Offline Freakshow

  • Superstar
  • ******
  • Posts: 7277
  • Adelaide, SA - looking for a "YZA" tank
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #8 on: September 21, 2012, 02:33:10 PM »
are you swaping in both gear shafts ?
74 Yamaha YZ's - 75 Yamaha YZ's
74 Yamaha  flattracker's
70  Jawa 2 valve speedway's

For sale -  PRE 75 Yamaha MX stuff, frame, motors and parts also some YAM DT1,2,A and Suzi TS bikes and stuff

Offline Tahitian_Red

  • Legend
  • *****
  • Posts: 1109
  • Mugen ME480
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #9 on: September 21, 2012, 02:42:29 PM »
So...If I swap in a complete YZ250B gear set and shafts I should good to go?  ;D
The "Factory Novice"
California, USA

'74 Suzuki TM100, '75 Bultaco 250 Pursang, '77 Honda XR75, '77 Suzuki RM125B, '77 Yamaha YZ400D, '79 Honda CR250RZ Moto-X Fox Replica, '83 Honda ME480RD Mugen

Offline Freakshow

  • Superstar
  • ******
  • Posts: 7277
  • Adelaide, SA - looking for a "YZA" tank
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #10 on: September 21, 2012, 02:45:39 PM »
tha same case so yes.
74 Yamaha YZ's - 75 Yamaha YZ's
74 Yamaha  flattracker's
70  Jawa 2 valve speedway's

For sale -  PRE 75 Yamaha MX stuff, frame, motors and parts also some YAM DT1,2,A and Suzi TS bikes and stuff

Offline firko

  • Superstar
  • ******
  • Posts: 6578
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #11 on: September 21, 2012, 03:28:12 PM »
Quote
So...If I swap in a complete YZ250B gear set and shafts I should good to go? 
The whole shebang goes straight in. That's exactly what I fitted to my DT1 motor.....along with the clutch/primary drive and some other stuff
'68 Yamaha DT1 enduro, '69 Yamaha 'DT1 from Hell' '69 DT1'Dunger from Hell, '69 Cheney Yamaha 360, 70 Maico 350 (2 off), '68 Hindall Ducati 250, Hindall RT2MX, Hindall YZ250a , Cycle Factory RT2MX flat tracker, Yamaha 1T250J, Maico 250 trials, '71, Boyd and Stellings TM400, Shell OW72,750 Yamaha

Offline Tahitian_Red

  • Legend
  • *****
  • Posts: 1109
  • Mugen ME480
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #12 on: October 08, 2012, 01:45:02 AM »
How well will a '75 MX250B gear set work in the RT-1?  The only YZ250/360 A/B gear sets I've found are pricey.  ;D
The "Factory Novice"
California, USA

'74 Suzuki TM100, '75 Bultaco 250 Pursang, '77 Honda XR75, '77 Suzuki RM125B, '77 Yamaha YZ400D, '79 Honda CR250RZ Moto-X Fox Replica, '83 Honda ME480RD Mugen

Offline vandy010

  • Legend
  • *****
  • Posts: 1982
  • #789 MX125a BMCC Brisbane
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #13 on: October 08, 2012, 10:18:07 AM »
How well will a '75 MX250B gear set work in the RT-1?  The only YZ250/360 A/B gear sets I've found are pricey.  ;D
off the top of my head i can't say for sure but from a vague memory, the shafts are different but the cogs will swap over to the RT shaft but i believe the shift forks are different too, which means the cog that has the machined area for the shift fork, well that machined area is a different diameter.
if that makes sense.
so i'd guess (in my best weather man voice)
theres a possible slight chance :D
"flat bickie"

Offline Tahitian_Red

  • Legend
  • *****
  • Posts: 1109
  • Mugen ME480
    • View Profile
Re: Pre 75 Yamaha Trans Conversions
« Reply #14 on: November 06, 2012, 12:02:38 PM »
Well I found a 73-74 MX250 gear set. 

So, reviewing the posts it looks like I only need to replace 4th gear (both shafts?) with the one from the RT-1 shaft.  ???
The "Factory Novice"
California, USA

'74 Suzuki TM100, '75 Bultaco 250 Pursang, '77 Honda XR75, '77 Suzuki RM125B, '77 Yamaha YZ400D, '79 Honda CR250RZ Moto-X Fox Replica, '83 Honda ME480RD Mugen